www.CVOHARLEY.com

Please login or register.

Login with username, password and session length
Advanced search  
Pages: [1] 2 3  All

Author Topic: Oil Pan Gasket Leak -- Changing Pan in the Frame  (Read 16909 times)

0 Members and 2 Guests are viewing this topic.

Twolanerider

  • 25K CVO Member
  • *****
  • Offline Offline
  • Posts: 50581
  • EBCM #1.5 Emeritus DSP # ? Critter Gawker #?
    • MO


    • CVO1: 2000 Triple Red Screamin' Eagle Road Glide
    • CVO2: 2002 Candy Brandywine Screamin' Eagle Road King
    • CVO3: 1999 Arresting Red FXR2
Oil Pan Gasket Leak -- Changing Pan in the Frame
« on: June 28, 2010, 06:02:48 PM »
Never had one of these leak before.  For a month have been chasing this oil leak.  Never could isolate it.  Wasn't drain plug o-ring, the fitting for the sending unit or the sending unit itself.  After a dinner ride or some other local half-a-tank run there'd be just enough oil spread around you couldn't tell precisely where it was coming from.  Could wipe it all down and it wouldn't leak sitting in the garage.  Had to be moving.  Crankcase vents were clear.  Even worried about seepage between engine cases but that wasn't it.

Finally decided to chase it down this afternoon.  20 mile run had the oil spread just far enough it couldn't be isolated.  Cleaned it up and a 10 mile run had it wind blown again that the spread made it unsure.  Cleaned up again and a five mile run left it clean enough to find.  Right-forward corner of the oil pan.  Stupid thing.

Never had an oil pan off in the frame before.  Assuming it'll come out with the back tire off.  Anyone know if swingarm has to come out also?

No big hurry.  A lot going on around here.  Appearance to the contrary it is a small leak.  Not worried about riding it but the Road Glide is here too.  So it'll get done sometime.

Stupid oil leak.....
« Last Edit: July 12, 2010, 12:56:30 AM by Twolanerider »
Logged

Twolanerider

  • 25K CVO Member
  • *****
  • Offline Offline
  • Posts: 50581
  • EBCM #1.5 Emeritus DSP # ? Critter Gawker #?
    • MO


    • CVO1: 2000 Triple Red Screamin' Eagle Road Glide
    • CVO2: 2002 Candy Brandywine Screamin' Eagle Road King
    • CVO3: 1999 Arresting Red FXR2
Re: Oil Pan Gasket Leak -- That's a New One on Me
« Reply #1 on: June 28, 2010, 06:04:22 PM »
If I remember right the OE gasket is a metal gasket.  Anyone used something known to be better or is that the best choice?  Pan gasket isn't someone one uses often so not a lot of replacement experience.

Stupid oil leak.
Logged

Twolanerider

  • 25K CVO Member
  • *****
  • Offline Offline
  • Posts: 50581
  • EBCM #1.5 Emeritus DSP # ? Critter Gawker #?
    • MO


    • CVO1: 2000 Triple Red Screamin' Eagle Road Glide
    • CVO2: 2002 Candy Brandywine Screamin' Eagle Road King
    • CVO3: 1999 Arresting Red FXR2
Re: Oil Pan Gasket Leak -- That's a New One on Me
« Reply #2 on: June 28, 2010, 06:06:22 PM »
At least the bike has good timing.  A rear caliper is on the way back from Chrome Masters right now.  So that can go on at the same time.  Guess can also replace the pan with this red one that was powder coated when the cylinders and heads were done a couple years ago.  Had always figured a "convenient" time would present to change it.  Apparently the bike got tired of waiting....
Logged

Twolanerider

  • 25K CVO Member
  • *****
  • Offline Offline
  • Posts: 50581
  • EBCM #1.5 Emeritus DSP # ? Critter Gawker #?
    • MO


    • CVO1: 2000 Triple Red Screamin' Eagle Road Glide
    • CVO2: 2002 Candy Brandywine Screamin' Eagle Road King
    • CVO3: 1999 Arresting Red FXR2
Re: Oil Pan Gasket Leak -- That's a New One on Me
« Reply #3 on: June 28, 2010, 06:07:01 PM »
Stupid oil leak.....
Logged

Fired00d

  • Global Moderator
  • 25K CVO Member
  • *****
  • Offline Offline
  • Posts: 32683
  • Orange & Black SEEG... Can it get any better?
    • VA


    • CVO1: FLHTCSE
Re: Oil Pan Gasket Leak -- That's a New One on Me
« Reply #4 on: June 28, 2010, 06:15:47 PM »
Quote from: Twolanerider on June 28, 2010, 06:07:01 PM
Stupid oil leak.....
You reckon it had anything to do w/the dead cat?? :wiseguy: :smartass2: :sneaky: :evilgrin: :smug: :nervous:

 :pumpkin:
Ride Safe,
Fired00d
 :fireman:
Logged
:pumpkin: 2004 Screamin’ Eagle Electra Glide :pumpkin:
Rinehart True Duals
SE Breather
SE Race Tuner
HogTunes Speakers
Zippers 575 Gear Drive Cams
Zippers Pro-Tapered Adjustable Push Rods
Zippers Oil Pressure Bypass Shim
Feuling Oil Pump
Feuling Lifters
Zumo 550 W/Flame Caps
Lyndall Z+ Brake Pads
CVOHarley Member #1234
PGR Member #754 (Since '05)
Proud Member EBCM #2.0

Twolanerider

  • 25K CVO Member
  • *****
  • Offline Offline
  • Posts: 50581
  • EBCM #1.5 Emeritus DSP # ? Critter Gawker #?
    • MO


    • CVO1: 2000 Triple Red Screamin' Eagle Road Glide
    • CVO2: 2002 Candy Brandywine Screamin' Eagle Road King
    • CVO3: 1999 Arresting Red FXR2
Re: Oil Pan Gasket Leak -- That's a New One on Me
« Reply #5 on: June 28, 2010, 06:20:11 PM »
Quote from: Fired00d on June 28, 2010, 06:15:47 PM
You reckon it had anything to do w/the dead cat?? :wiseguy: :smartass2: :sneaky: :evilgrin: :smug: :nervous:

 :pumpkin:
Ride Safe,
Fired00d
 :fireman:



So you're saying that the root of all evil is pu....... wait, I better stop right there :oops: .      :huepfenlol2:
Logged

Twolanerider

  • 25K CVO Member
  • *****
  • Offline Offline
  • Posts: 50581
  • EBCM #1.5 Emeritus DSP # ? Critter Gawker #?
    • MO


    • CVO1: 2000 Triple Red Screamin' Eagle Road Glide
    • CVO2: 2002 Candy Brandywine Screamin' Eagle Road King
    • CVO3: 1999 Arresting Red FXR2
Re: Oil Pan Gasket Leak -- That's a New One on Me
« Reply #6 on: June 28, 2010, 06:20:39 PM »
oh yeah, stupid oil leak.....
Logged

Fired00d

  • Global Moderator
  • 25K CVO Member
  • *****
  • Offline Offline
  • Posts: 32683
  • Orange & Black SEEG... Can it get any better?
    • VA


    • CVO1: FLHTCSE
Re: Oil Pan Gasket Leak -- That's a New One on Me
« Reply #7 on: June 28, 2010, 06:24:19 PM »
Quote from: Twolanerider on June 28, 2010, 06:20:11 PM


So you're saying that the root of all evil is pu....... wait, I better stop right there :oops: .      :huepfenlol2:
It's been said before.... it's brought many a man down... just sayin' :nixweiss:

Never heard it causing a leak.... maybe a drip or two... :oops: :huepfenlol2:

 :pumpkin:
Ride Safe,
Fired00d
 :fireman:
Logged
:pumpkin: 2004 Screamin’ Eagle Electra Glide :pumpkin:
Rinehart True Duals
SE Breather
SE Race Tuner
HogTunes Speakers
Zippers 575 Gear Drive Cams
Zippers Pro-Tapered Adjustable Push Rods
Zippers Oil Pressure Bypass Shim
Feuling Oil Pump
Feuling Lifters
Zumo 550 W/Flame Caps
Lyndall Z+ Brake Pads
CVOHarley Member #1234
PGR Member #754 (Since '05)
Proud Member EBCM #2.0

Twolanerider

  • 25K CVO Member
  • *****
  • Offline Offline
  • Posts: 50581
  • EBCM #1.5 Emeritus DSP # ? Critter Gawker #?
    • MO


    • CVO1: 2000 Triple Red Screamin' Eagle Road Glide
    • CVO2: 2002 Candy Brandywine Screamin' Eagle Road King
    • CVO3: 1999 Arresting Red FXR2
Re: Oil Pan Gasket Leak -- That's a New One on Me
« Reply #8 on: June 28, 2010, 06:28:39 PM »
Quote from: Fired00d on June 28, 2010, 06:24:19 PM
It's been said before.... it's brought many a man down... just sayin' :nixweiss:

Never heard it causing a leak.... maybe a drip or two... :oops: :huepfenlol2:

 :pumpkin:
Ride Safe,
Fired00d
 :fireman:

Huh, a guy would think the old problems wouldn't be so bad if she used synthetic flui.....   

           wait.......

                      this could go so wrong so fast......
Logged

Twolanerider

  • 25K CVO Member
  • *****
  • Offline Offline
  • Posts: 50581
  • EBCM #1.5 Emeritus DSP # ? Critter Gawker #?
    • MO


    • CVO1: 2000 Triple Red Screamin' Eagle Road Glide
    • CVO2: 2002 Candy Brandywine Screamin' Eagle Road King
    • CVO3: 1999 Arresting Red FXR2
Re: Oil Pan Gasket Leak -- That's a New One on Me
« Reply #9 on: June 28, 2010, 06:29:25 PM »






stupid oil leak




Logged

sadunbar

  • 10K CVO Member
  • ****
  • Offline Offline
  • Posts: 11416
  • EBCM # Stealth - SSBS # 1.1 - SoA # Z&E2525 .01%
    • IL


    • CVO1: 2007 FLHTCUSE2
    • CVO2: 2000 FXR4
Re: Oil Pan Gasket Leak -- That's a New One on Me
« Reply #10 on: June 28, 2010, 07:31:56 PM »
Quote from: Twolanerider on June 28, 2010, 06:02:48 PM
Never had one of these leak before.  For a month have been chasing this oil leak.  Never could isolate it.  Wasn't drain plug o-ring, the fitting for the sending unit or the sending unit itself.  After a dinner ride or some other local half-a-tank run there'd be just enough oil spread around you couldn't tell precisely where it was coming from.  Could wipe it all down and it wouldn't leak sitting in the garage.  Had to be moving.  Crankcase vents were clear.  Even worried about seepage between engine cases but that wasn't it.

Finally decided to chase it down this afternoon.  20 mile run had the oil spread just far enough it couldn't be isolated.  Cleaned it up and a 10 mile run had it wind blown again that the spread made it unsure.  Cleaned up again and a five mile run left it clean enough to find.  Right-forward corner of the oil pan.  Stupid thing.

Never had an oil pan off in the frame before.  Assuming it'll come out with the back tire off.  Anyone know if swingarm has to come out also?

No big hurry.  A lot going on around here.  Appearance to the contrary it is a small leak.  Not worried about riding it but the Road Glide is here too.  So it'll get done sometime.

Stupid oil leak.....

yep...

Bet that makes it a REALLY stupid oil leak.......
Logged
2007 Screamin Eagle Ultra Classic - Light Candy Cherry and Black Ice
Screamin Eagle 120r
Revolution Performance EMS
Fuel Moto Jackpot headpipes and 4.5" Pro Touring Mufflers
HPI 55mm Throttle Body w/5.3 injectors
BDL clutch w/VPC92T
Traxxion AK-20
Legend Air Suspension
Brembo Brake Calipers/Rotors
Garmin Zumo
575 Chubby's
Bushtec Quantum

hogasm

  • Guest
Re: Oil Pan Gasket Leak -- That's a New One on Me
« Reply #11 on: June 28, 2010, 08:03:19 PM »
Had mine out the other day

It is a great time to replace swing arm pivot blocks

Chrome the removed swing arm

Chrome the axle and nut

Align motor again


what no chrome :nixweiss:tightwad
Logged

Twolanerider

  • 25K CVO Member
  • *****
  • Offline Offline
  • Posts: 50581
  • EBCM #1.5 Emeritus DSP # ? Critter Gawker #?
    • MO


    • CVO1: 2000 Triple Red Screamin' Eagle Road Glide
    • CVO2: 2002 Candy Brandywine Screamin' Eagle Road King
    • CVO3: 1999 Arresting Red FXR2
Re: Oil Pan Gasket Leak -- That's a New One on Me
« Reply #12 on: June 28, 2010, 09:16:00 PM »
Quote from: hogasm on June 28, 2010, 08:03:19 PM
Had mine out the other day

It is a great time to replace swing arm pivot blocks

Chrome the removed swing arm

Chrome the axle and nut

Align motor again


what no chrome :nixweiss:tightwad

Can align motor again.  So don't care about that one way or the other.  It's just that whole law-of-unintended-consequences thing.  The thing rides like it's on rails now.  Just hate to screw with more than I have to.  Especially since all the parts inside are only 10k or so old anyway.

At Chrome Masters is a back caliper and an axle.  Two calipers actually.  One for this bike and one for the eventual Road King project.  The axle was for the road king but I'll use it here too.  Then just send this one's out to get chromed again.  I'm not a big fan of chromed swing arms though.  Seen adjusters slip on them too often.  So that part will stay powder coat. 

Ok, you can Scott convinced me.  Whenever I get around to it will count on pulling it all down. 






Stupid oil leak.
Logged

Twolanerider

  • 25K CVO Member
  • *****
  • Offline Offline
  • Posts: 50581
  • EBCM #1.5 Emeritus DSP # ? Critter Gawker #?
    • MO


    • CVO1: 2000 Triple Red Screamin' Eagle Road Glide
    • CVO2: 2002 Candy Brandywine Screamin' Eagle Road King
    • CVO3: 1999 Arresting Red FXR2
Re: Oil Pan Gasket Leak -- That's a New One on Me
« Reply #13 on: June 28, 2010, 09:17:19 PM »



.... but the red oil pan will look cool to anyone who is ever passed out on the ground and wakes up looking up under the bike  :apple: !
Logged

Twolanerider

  • 25K CVO Member
  • *****
  • Offline Offline
  • Posts: 50581
  • EBCM #1.5 Emeritus DSP # ? Critter Gawker #?
    • MO


    • CVO1: 2000 Triple Red Screamin' Eagle Road Glide
    • CVO2: 2002 Candy Brandywine Screamin' Eagle Road King
    • CVO3: 1999 Arresting Red FXR2
Re: Oil Pan Gasket Leak -- That's a New One on Me
« Reply #14 on: June 28, 2010, 09:17:48 PM »





however....
 

            stupid oil leak........
Logged
Pages: [1] 2 3  All
« previous next »
 

Page created in 0.222 seconds with 21 queries.